Upgrade the 5R110 transmission in your 2003-2007 Ford 6.0L Powerstroke with the ATS Built 5R110 Transmission. Innovation and technology set ATS apart from the rest. Between their engineering team, and their transmission specialists, ATS has logged thousands of hours in building, testing, and manufacturing to bring you the best transmission worth of bolting up behind your legendary Powerstroke engine. ATS transmissions include extensive modifications so you can put power to the ground whether you're towing, daily driving, or on the race track. Backed by the ATS 5-year, 500,000 mile warranty, this transmission comes ready to install and is dyno tested before shipping.
ATS 5R110 Build (All Stages)
- Upgraded Pump - Machined housing for larger and higher quality components for better fluid flow
- Shimmed PR Valve - Maintains higher line pressures
- 5 Forward GPZ Clutches
- 5 Intermediate GPZ Clutches
- 5 Overdrive GPZ Clutches
- 6 Direct GPZ Clutches
- Custom Machined Clutch Pack Apply Plates
- Teflon Seal Rings
- Custom Machined Direct Drum & Upgraded Bushing
- New OEM Center Support
- New OEM Speed Sensors
- All Bushings & Bearings Replaced
- All New Gaskets & Seals
- All New Filter
- Modified Solenoids
Build Date Guide: 2003-2007 Transmission 6.0L Engine - For trucks built from Feb-2003 to Jan-2007
Note: Transmission only. Deep Pan & Torque Converter sold separately.
This ATS Automatic Transmission carries a FIVE YEAR/FIVE HUNDRED THOUSAND MILE (5 yr/500,000 mile) Warranty. This Warranty shall not apply to any automatic transmission that has been improperly stored or installed This Warranty shall not apply to misapplication, improper operating conditions, accidents, or neglect. This Warranty shall not apply to an automatic transmission that has been improperly repaired, maintained and/or altered by the owner or his agent/tech. Most importantly, all transmission shafts are not covered by this Warranty on any transmission due to the capability of certain situations to cause stress-loads beyond the structural ability of the shaft. ATS’ Automatic Transmission Warranty is NOT transferable. It is mandatory for implementation of this warranty that line pressures are tested at time of install. ATS will not pay for any fluids replaced in the event of a transmission failure.