Products Showing Parts for — {{ }}

No Results Showing Parts for — {{ }}
Part #:

Swamps Heavy Duty Rebuilt 48V FICM

2003-2007 Ford 6.0L Powerstroke
Part #:
FROM 485
Accept Core Charge * VIEW CORE RETURN POLICY *
Our Recommendations Compatible Products
Scroll to View More


Swamps Diesel 48v Fuel Injection Control Modules come pre-programmed with the latest factory Ford programming. These units are fully tested (on a test bench, actually sending signals to 8 fuel injectors), with a 30 amp load, and are ready to install & drive away. No reprogramming by Ford is required.

PHP FICM Tuning:
All PHP tuning utilizes the latest inductive heating strategies strategies for improved cold temperature startups and operation. With 4 power levels to chose from (Economy, Atlas 40, Atlas 80, and Hercules) our programs compliment any ECM tuning, whether it is stock or modified. 
  • Economy: Most users see fuel economy gains as well as improved tip-in throttle response and better overall driveability from, idle up to through 3500 RPM. We also eliminate that annoying injector post buzz.
  • Atlas 40: Gains of 40hp can be expected along with greater off-idle throttle response and slightly improved fuel economy over most stock FICM software versions
  • Atlas 80: Gains of 80hp can be expected with this flash as well as modersately increased fueling strategies, which greatly improve bottom end acceleration and throttle response throughout the power band.  
  • Hercules 100: Gains of 100hp have been recorded on the dyno with a slightly modified vehicle. With aggressive fueling rates and crisp throttle response, this software flash is the right choice if you are looking to squeeze every least hp out of your 6.0L.
  • 48V FICM
  • Pre-Programmed
  • Fully Tested 
  • Direct Replacement 

Note On Cores: Swamps will only accept a FICM if it meets the following guidelines, No external case/connector damage. No Water/coolant contamination, etc. Sending a core that has been soldered on will void a full core credit.


  • MFG. Number48VFICM
  • Manufacturer NameSwamps Diesel
  • Shipping Weight2.00 lb.
  • Shipping Length6 in.
  • Shipping Width8 in.
  • Shipping Height3 in.


Be the first to rate this item!

Write Review

Customer Photos

Customer Photos

See what others built Submit your photo

Questions and Answers

Ask XDP a Question about this product (Allow 24-48 hours for reply)

Most Popular Questions

Do I need to totally disconnect the batteries when removing the 6.0 ficm or just disconnect the ground.? Batteries hang under frame. Huge job to remove the the positive connection.
View Staff Answer 

You can just disconnect both negative battery cables.

Fault code (U0306) after installing?
View Staff Answer 

The fault code #U306 (Software incapability with FICM) is normal with FICM’s that were not flashed specifically for you vehicles VIN #. This code is nothing to worry about and will not trigger a check engine light.

Emissions Notice

This product is not legal for sale or street use in California. Certain aftermarket products are subject to governmental emission standards regulated by the California Air Resources Board. In order for these products to be legal on a specific vehicle in California, the part number must receive a CARB Executive Order (EO) number. This number makes the part legal for use only on specific years, makes and models of vehicles. A decal with CARB EO number for these parts must be displayed in the engine bay to satisfy smog inspection requirements.